Solar Water Heater Maintenance Checklist

Satisfactory not satisfactory 2 quantity of hot water supply.

Solar water heater maintenance checklist.

Solar water heating system maintenance and repair periodic inspection list. Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for. Preventing scaling and corrosion. Satisfactory not satisfactory 3 constant temperature e g.

Annual water heater maintenance checklist drain and flush tank drain and flush tank very important for gas water heaters. Two major factors affecting the performance of properly sited and installed solar. Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector. Drain the water from the hot water pipe.

Check to make sure the water to the hot water heater has been completely shut off. If it is then you are set to refill the tank. Whether the tank is gas or electric turn off its heating source the night before. Install pump onto the water heater discharge using pipe fitting.

Close drain valve and open cold water supply valve. Turn off cold water supply and open drain valve. Turn off the heat. Regularly scheduled maintenance should include.

Open a hot water. If that is too. Be sure to check the water draining out and make sure it is clear. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater.

The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel. Here are some suggested inspections of solar system components. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out. Let the water run until it stops flowing.

Before you begin inspect all of the valves. When calling for assistance please have the following. Use a solution of dish soap and warm. If water is milky drain entire tank.

Disconnect the hot water heater at the hot water discharge. Allow a few gallons worth of water to drain. Don t miss the temperature and pressure valves. Also read your owner s manual.

Drain 2 3 gallons of water.